| Citation ID |
01001A |
| Citaton Type |
Serious |
| Standard Cited |
19100132 D02 |
| Issuance Date |
2013-02-21 |
| Abatement Due Date |
2013-04-09 |
| Current Penalty |
1500.0 |
| Initial Penalty |
3000.0 |
| Final Order |
2013-03-15 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| Gravity |
1 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.132(d)(2): The employer did not verify, through a written certification, that the required workplace hazard assessment had been performed: Facility: The workplace hazard assessment did not include all the tasks, such as ( but not limted to) the personal protective equipment for changing the propane tank on the fork lift. |
|
| Citation ID |
01001B |
| Citaton Type |
Serious |
| Standard Cited |
19100138 B |
| Issuance Date |
2013-02-21 |
| Abatement Due Date |
2013-03-19 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2013-03-15 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| Gravity |
1 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.138(b): The employer did not base the selection of the appropriate hand protection on an evaluation of the performance characteristics of the hand protection relative to the task(s) to be performed, conditions present, duration of use, and the hazards and potential hazards identified. Facility: The employer did not select and require employee to wear appropriate hand protection while preforming tasks, such as (but not limited to) changing the tanks of propane fuel. |
|
| Citation ID |
01002A |
| Citaton Type |
Serious |
| Standard Cited |
19100134 C01 |
| Issuance Date |
2013-02-21 |
| Abatement Due Date |
2013-04-19 |
| Current Penalty |
2500.0 |
| Initial Penalty |
5000.0 |
| Final Order |
2013-03-18 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.134(c)(1): A written respiratory protection program that included the provisions in 29 CFR 1910.134(c)(1)(i) - (ix) with worksite specific procedures was not established and implemented for required respirator use. Facility: The employer did not establish and implement a written respiratory program where employees were required to wear supplied air respirators. |
|
| Citation ID |
01002B |
| Citaton Type |
Serious |
| Standard Cited |
19100134 E01 |
| Issuance Date |
2013-02-21 |
| Abatement Due Date |
2013-04-19 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2013-03-18 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.134(e)(1): The employer did not provide a medical evaluation to determine the employee's ability to use a respirator, before the employee is required to use the respirator in the workplace. Facility: The employer did not provide a medical evaluation to the employees, who were required to use air supplied to determine the employee's ability. |
|
| Citation ID |
01003A |
| Citaton Type |
Other |
| Standard Cited |
19100134 I01 II |
| Issuance Date |
2013-02-21 |
| Abatement Due Date |
2013-03-19 |
| Current Penalty |
1000.0 |
| Initial Penalty |
7000.0 |
| Final Order |
2013-03-15 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.134(i)(1)(ii): Breathing air did not meet requirements for Grade "D" breathing air as described in the ANSI/Compressed Gas Association Commodity Specification G-7.1-1989. Facility: The breathing air, used by employees wearing supplied air quality respirators was not tested to ensure meeting the standards of Grade "D" air. |
|
| Citation ID |
01003B |
| Citaton Type |
Other |
| Standard Cited |
19100134 I05 III |
| Issuance Date |
2013-02-21 |
| Abatement Due Date |
2013-03-19 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2013-03-15 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.134(i)(5)(iii): The compressor's sorbent bed and filters were not maintained and replaced or refurbished periodically as instructed by the manufacturer. Facility: Facility: The pertinent parts of the air compressor used to supply breathing air for the employees wearing supplied air respirators was not maintained and replaced and/or refurbished periodically per manufacturers recommendations. |
|
| Citation ID |
01004A |
| Citaton Type |
Serious |
| Standard Cited |
19100147 C01 |
| Issuance Date |
2013-02-21 |
| Abatement Due Date |
2013-05-18 |
| Current Penalty |
2500.0 |
| Initial Penalty |
5000.0 |
| Final Order |
2013-03-18 |
| Nr Instances |
1 |
| Nr Exposed |
10 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.147(c)(1): The employer did not establish a program consisting of an energy control procedure, employee training and periodic inspections to ensure that before any employee performed any servicing or maintenance on a machine or equipment where the unexpected energy, startup or release of stored energy could occur and cause injury, the machine or equipment shall be isolated from the energy source and rendered inoperative: Facility: The employer did not establish and implement a site specific energy control program consisting of machine specific step-by-step energy control procedures, employee training and more for employees servicing and maintenance of equipment, such as (but not limited to) vertical post mixers, and 3-roll mill. |
|
| Citation ID |
01004B |
| Citaton Type |
Serious |
| Standard Cited |
19100147 C04 |
| Issuance Date |
2013-02-21 |
| Abatement Due Date |
2013-05-19 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2013-03-18 |
| Nr Instances |
1 |
| Nr Exposed |
10 |
| Gravity |
1 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.147(c)(4): Procedures were not developed, documented, and utilized for the control of potentially hazardous energy when employees were engaged in activities covered by this section: Facility: The employer did not establish and implement written site and machine specific step-by-step hazardous energy control procedures for employees servicing and performing maintenance of equipment, such as (but not limited to) verical post mixers and 3-roll mill. |
|
| Citation ID |
01004C |
| Citaton Type |
Serious |
| Standard Cited |
19100147 C07 I |
| Issuance Date |
2013-02-21 |
| Abatement Due Date |
2013-05-19 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2013-03-18 |
| Nr Instances |
1 |
| Nr Exposed |
10 |
| Gravity |
1 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.147(c)(7)(i): The employer did not provide adequate training to ensure that the purpose and function of the energy control program was understood by employees 29 CFR 1910.147(c)(4): Procedures were not developed, documented, and utilized for the control of potentially hazardous energy when employees were engaged in activities covered by this section: Facility: The employees, as "authorized, affected and other" types were not provided with appropriate training and information in the hazardous energy control lockout/tagout procedures during servicing and performing maintenance of equipment, such as (but not limited to) vertical post mixers and 3-roll mill. |
|
| Citation ID |
01005 |
| Citaton Type |
Serious |
| Standard Cited |
19100176 B |
| Issuance Date |
2013-02-21 |
| Abatement Due Date |
2013-03-19 |
| Current Penalty |
2500.0 |
| Initial Penalty |
5000.0 |
| Final Order |
2013-03-15 |
| Nr Instances |
1 |
| Nr Exposed |
36 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.176(b): Material stored in tiers was not stacked, blocked, interlocked or limited in height so that it was stable and secure against sliding and collapse: Warehouse: The employer did not ensure that a stack of cardboard pallets were stacked to prevent collapse. |
|
| Citation ID |
02001 |
| Citaton Type |
Other |
| Standard Cited |
19100134 K06 |
| Issuance Date |
2013-02-21 |
| Abatement Due Date |
2013-03-19 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2013-03-15 |
| Nr Instances |
1 |
| Nr Exposed |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.134(k)(6): The employer did not provide the basic advisory information on respirators, as presented in Appendix D of 29 CFR 1910.134, in written or oral format to employees who wear respirators when such use was not required by the employer.: Facility: The employees who were voluntary wearing N95 respirators were neither given a copy of Appendix D information nor an explanation of its contents. |
|
